Recent Posts

21

Mk5 General Area / Re: rs3 lpfp

« Last post by pudding on May 03, 2024, 10:37:09 pm »

Nope. You need either the TTRS pump module or the TorqByte aftermarket one.  The stock PWM controller isn't man enough to run an RS pump.

Yes the LPFP maps will need recalibrating.

The GTI fuel level sender should fit on but AKS tuning can advise on that.

22

Mk5 General Area / Re: Manual transmission oil type

« Last post by pudding on May 03, 2024, 10:33:04 pm »

There are 2 sizes of end cap, just measure the one you have currently and order that size. 79mm and 84mm iirc.

Don't know what you mean by shim. If you mean shaft play shim kit, you don't need it on an 08 car.  Only 04-06 cars need that.

Use the  G 052 171 A2 stuff.  Yes its expensive but its much better than cheaper alternatives.

23

Mk5 General Area / Re: sorts cat to decat without tune?

« Last post by pudding on May 03, 2024, 10:27:35 pm »

Can't see why not... you'll just get an engine light on probably with p0420 code for cat efficiency.

Yep. The ECU doesn't really care about cat efficiency and will only affect drivability a tiny bit, but it has to throw the EML by law.

24

Mk5 General Area / Re: Clicking/Clunking noise when coming to a stop or setting off

« Last post by pudding on May 03, 2024, 10:21:29 pm »

Yeah if it's not crunchy dried out inner CV joints, it will be subframe movement.

25

Mk5 General Area / Re: Intake Manifold Runner Control Error P3137 - Will my engine go boom?

« Last post by pudding on May 03, 2024, 10:18:56 pm »

Nope, no danger of wrecking the engine.  Default position in the event of runner flap motor failure is flaps fully open. If the flaps were stuck closed you would know about it as you'd have no power past 2000rpm.

Try a basic settings/adaptation in VCDS for the flappy flappers a few times and check you get "OK".  If no OK, the motor is buggered. When doing that test, you should see the motor actuator arm moving.

10 days to go flat isn't bad tbh.  If it went flat in 3 days then you definitely have a duff battery or an alternator charging issue. If the battery measures more than 12V with the car gone to sleep, I wouldn't waste money on a battery.

26

Mk5 General Area / Re: K04 Conversion - Do you ever regret it? How is it for daily driving?

« Last post by pudding on May 03, 2024, 10:12:44 pm »

All looks good - but you will have to be careful, from what I read online upgrading turbo without injectors can lead to running too lean which is dangerous for the engine. Make sure the tuner is aware you are on stock injectors and you are limited. Perhaps 300hp is too optimistic without the fuel related mods?

Also the video you posted is private so I can't check it out.

It's all good in the hood. Just pull the N75 plug and you'll be restricted to 8 psi of boost and then fit the K04 injectors at the mapping place before the remap.  Probably makes more sense to fit the K04 injectors at home though and save on labour costs, but either way, it's drivable on K03 or K04 squirters before the mapping.

The main issue is whether or not the mapper can work around the rail pressure sensor.  Some insist on using the K04 sensor, and some can rescale the K03 sensor.

27

Mk5 General Area / Re: 62% insurance increase anyone?

« Last post by pudding on May 03, 2024, 10:03:45 pm »

Yeah the insurance on my 330d went from £665 last year to £1250 this year  Mental.

Cheapest quote on Go F'ck yourself was £800 through a no name broker with virtually no cover 

Car parts and labour costs have increased is their excuse. So what. My skills at work have improved in the last year, that doesn't mean I can demand a 62% pay rise! Greedy forkers.

The whole point of insurance is we all pay into a contingency pot to cover life's unexpected events, so what the fook are they doing with all that money?  Oh the world has changed slightly, boo hoo, 9848% more cash from you please. Utter runts, grrrrrrr.

28

Mk5 General Area / Re: Mk5 GT impossible tapping noise

« Last post by Von on May 03, 2024, 06:03:54 pm »

Cheers, safe to say a turbo upgrade is off the map.

29

Mk5 General Area / Re: Mk5 GT impossible tapping noise

« Last post by ZoliWorks on May 03, 2024, 06:02:28 pm »

Also, genuine question, since my turbo is pretty much done for, would a bigger turbo be an easy upgrade, or am i gonna have to replace injectors and so on?

As someone who's done it on the 1.4 122hp CAXA, I'd advise against it. I've installed the turbocharger off of a CAVD (160hp), no cat downpipe, full 63mm exhaust, front mount intercooler kit, watercooled-intercooler block-off, r8 coils mod, ngk 1 step colder plugs and probably a few minor things I'm forgetting. The car was able to achieve 240hp on 100 octane and a little over 320nm torque.

It's fun for a while but you get bored of it fast. If you want fun, the 1.4 is not it. There's no replacement for displacement. You'll be spending upwards of 6k to make your car go faster than a stock GTI, who then can get a remap for $400 and beat you anyway. It's a small engine with a lack of low-down power.

Plus, you, on the BLG, should be able to just get a remap and get 200-210hp, so is it really worth investing all that money for 30 extra? Get a GTI, you wont regret it if you want fun, you will regret it if you want fuel economy..


TLDR: Fix your turbo rather than upgrade, not worth the investment.

30

Mk5 General Area / Re: Mk5 GT impossible tapping noise

« Last post by Von on May 03, 2024, 05:53:43 pm »

The tapping is only audible when revving the engine up to 2k rpm, you dont hear it on deccel. I managed to replace the oil pump and rod bearings, noise isnt gone, and another problem popped up, the car starts perfectly fine the first time, then, if you shut it off, it wont start for a minute or so, after which it will start again, any idea whats causing that?