MK5 Golf GTI

All Things Mk5 => Mk5 General Area => Topic started by: edd666999 on August 22, 2011, 10:49:09 am

Title: 2 errors, any ideas?
Post by: edd666999 on August 22, 2011, 10:49:09 am: Address 09: Cent. Elect. Labels: 3C0-937-049-23-H.lbl
Part No SW: 3C0 937 049 E HW: 3C0 937 049 E
Component: Bordnetz-SG H37 1002
Revision: 00H37000 Serial number: 00000003994074
Coding: E58D0F2700041500001400001400000000087F075C
Shop #: WSC 00000 785 00200
VCID: 2B5FACABF395

Part No: 1K2 955 119 C
Component: Wischer VW350 013 0402
Coding: 00063445
Shop #: WSC 00000

Part No: 1K0 955 559 T
Component: RegenLichtSens 011 1110
Coding: 00207646
Shop #: WSC 00000

1 Fault Found:
00987 - Lamp for Brake Light; Left (M9)
012 - Electrical Fault in Circuit - Intermittent
Freeze Frame:
Fault Status: 00101100
Fault Priority: 1
Fault Frequency: 25
Reset counter: 61
Mileage: 81700 km
Time Indication: 0

Freeze Frame:
ON
Voltage: 14.25 V
ON
ON
OFF
OFF
OFF

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1K0-909-605.lbl
Part No SW: 1K0 909 605 R HW: 1K0 909 605 R
Component: 38 AIRBAG VW8 018 2200
Revision: 02018000 Serial number: 0038MD0A5D4Z
Coding: 0013112
Shop #: WSC 01269 785 00200
VCID: 3B7F9CEB03F5

1 Fault Found:
01218 - Side Airbag Igniter; Passenger Side (N200)
001 - Upper Limit Exceeded - Intermittent - MIL ON

I basically get a rear left brake light out error intermittantly and replacing the bulb doesn't help.

And I also get thr air bag light on, clearing the error make it go away for a week or 2.
Title: Re: 2 errors, any ideas?
Post by: Hedge on August 22, 2011, 11:57:37 am: The airbag one will be the wiring under the seat. Fairly common fault and should be done under warranty if applicable.

As for the the brake light, fook knows, torch it. :laugh:
Title: Re: 2 errors, any ideas?
Post by: edd666999 on August 22, 2011, 12:00:47 pm: No warranty left so what do I need to buy n replace?
Title: Re: 2 errors, any ideas?
Post by: bacillus on August 22, 2011, 12:59:10 pm: Quote from: Hedge on August 22, 2011, 11:57:37 am
As for the the brake light, fook knows, torch it. :laugh:

Is that looter talk?? :laugh:
Title: Re: 2 errors, any ideas?
Post by: Hedge on August 22, 2011, 01:51:21 pm: Quote from: edd666999 on August 22, 2011, 12:00:47 pm
No warranty left so what do I need to buy n replace?

I'm afraid unless someone knows better it's a dealer job.

Quote from: bacillus on August 22, 2011, 12:59:10 pm
Quote from: Hedge on August 22, 2011, 11:57:37 am
As for the the brake light, fook knows, torch it. :laugh:

Is that looter talk?? :laugh:

:signLOL:
Title: Re: 2 errors, any ideas?
Post by: edd666999 on July 04, 2012, 06:23:51 pm: So to bring this back to life! my airbag light now doesnt go out even after resetting it with vcds.

I have done this fix listed here:

http://forums.vwvortex.com/showthread.php?2815467

on my passenger seat. but still not resolved the issue? any ideas?
Title: Re: 2 errors, any ideas?
Post by: edd666999 on July 14, 2012, 02:12:30 am: no one?
Title: Re: 2 errors, any ideas?
Post by: skard on July 14, 2012, 02:29:31 am: Same fault on the same side?
Did the light go out after performing the work in the bulletin? Is there any possibility your work could have become undone?

Check the airbag plug from the seat to loom under the black plastic cap - see if the pins all line up and don't suffer from any sort of corrosion.
Title: Re: 2 errors, any ideas?
Post by: edd666999 on July 23, 2012, 07:19:50 am: Quote from: skard on July 14, 2012, 02:29:31 am
Same fault on the same side?
Did the light go out after performing the work in the bulletin? Is there any possibility your work could have become undone?

Check the airbag plug from the seat to loom under the black plastic cap - see if the pins all line up and don't suffer from any sort of corrosion.

didnt notice your reply.

same side yes passenger seat, plugs have been disconnected and checked! Its a MOT fail too and its in for a MOT at the moment...not sure where im going to go from here...
Title: Re: 2 errors, any ideas?
Post by: vRS Carl on July 23, 2012, 08:39:35 am: My last Octavia had this and had to have the igniter replaced! Luckily I had a warranty as its about £600 to fix iirc :scared:
Title: Re: 2 errors, any ideas?
Post by: edd666999 on July 23, 2012, 08:49:40 am: Quote from: vRS Carl on July 23, 2012, 08:39:35 am
My last Octavia had this and had to have the igniter replaced! Luckily I had a warranty as its about £600 to fix iirc :scared:

this is what i was afraid of. I will just buy a new interior if this is the case.
Title: Re: 2 errors, any ideas?
Post by: vRS Carl on July 23, 2012, 08:51:48 am: But that won't include an airbag igniter though will it?
Title: Re: 2 errors, any ideas?
Post by: titchy on July 23, 2012, 09:05:39 am: try a site http/:wwwbbareman thheres a guy on there called crasher bit of a genius on VAG. give as much info as pos. incthe stuff you put on here. you have to register but its free hope this helps
Title: Re: 2 errors, any ideas?
Post by: edd666999 on July 23, 2012, 07:49:00 pm: Quote from: vRS Carl on July 23, 2012, 08:51:48 am
But that won't include an airbag igniter though will it?

oh, i assumed its all inside the chair...
Title: Re: 2 errors, any ideas?
Post by: vRS Carl on July 23, 2012, 08:58:14 pm: Ignore me. I was thinking you were talking headlinings etc :grin:
Title: Re: 2 errors, any ideas?
Post by: edd666999 on July 23, 2012, 09:37:56 pm: Quote from: titchy on July 23, 2012, 09:05:39 am
try a site http/:wwwbbareman thheres a guy on there called crasher bit of a genius on VAG. give as much info as pos. incthe stuff you put on here. you have to register but its free hope this helps

managed to piece together what you meant and posted up! :signLOL: