MK5 Golf GTI
All Things Mk5 => Mk5 General Area => Topic started by: lukemk5gti on May 18, 2015, 09:40:12 am
-
Hi all, I've seen a good few of these in the past and I know there's a few solutions so maybe someone could shed some light.
I was driving 100miles at 120km/hr. Pulled over for 2 mins and left car running. Got back into car and merged again with motorway so I brought the revs to maybe 4K in each gear. When I got to 110km/hr the engine management light and traction control light came on and it went into limp mode.
I pulled over and turned engine off. When turning it off there was an awful heavy noise.
The car started up fine and has done since, as if nothing is any different.
(Note - I cleaned that mayo off the oil cap 2 days prior and gave the inside rim a wipe with a tissue because there was some slight crusty burnt on oil. I stopped doing this in fear that some of the gritty bits might fall into the oil itself. I am due my oil service which I had booked in this week already.)
Could those gritty bits have fallen in and blocked the mesh filter?
Oil pick up pipe?
High pressure fuel pump?
My vcds failed recently so I'm buying a genuine one this week, should be here in a few days so I'll scan then if VW won't do it for me with the oil change.
-
Anybody able to advise?
VCDS Version: Beta 15.5.0 (x64)
Data version: 20150510
www.Ross-Tech.com
Tuesday,19,May,2015,10:48:19:01600
Chassis Type: 1K (1K0)
Scan: 01 03 08 09 15 16 17 19 25 37 42 44 46 52 55 56 62 72
VIN: WVWZZZ1KZ6W016186 Mileage: 121380km-75422miles
00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
37-Navigation -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine Labels: 06F-907-115-AXX.lbl
Part No SW: 1K0 907 115 HW: 1K0 907 115
Component: 2.0l R4/4V TFSI G00 0070
Revision: --H01--- Serial number: VWZ7Z0E2229144
Coding: 0403000318070160
Shop #: WSC 00840 941 80257
VCID: 63C5EBB0A253F827F2-8036
2 Faults Found:
001089 - EVAP Emission Control Sys
P0441 - 002 - Incorrect Flow - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 0
Fault Frequency: 8
Reset counter: 255
Mileage: 116214 km
Time Indication: 0
Date: 2000.00.00
Time: 15:23:48
Freeze Frame:
RPM: 834 /min
Load: 17.2 %
Speed: 0.0 km/h
Temperature: 77.0°C
Temperature: 28.0°C
Absolute Pres.: 1000.0 mbar
Voltage: 14.097 V
004917 - Engine Torque Monitor 2
P1335 - 008 - Control Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 0
Fault Frequency: 1
Reset counter: 255
Mileage: 121263 km
Time Indication: 0
Date: 2000.00.00
Time: 16:14:59
Freeze Frame:
RPM: 2723 /min
Load: 69.0 %
Speed: 110.0 km/h
Temperature: 93.0°C
Temperature: 17.0°C
Absolute Pres.: 1000.0 mbar
Voltage: 14.478 V
Readiness: 0000 0000
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No SW: 1K0 907 379 Q HW: 1K0 907 379 Q
Component: ESP FRONT MK60 0102
Revision: 00T12001
Coding: 0004738
Shop #: WSC 01279 785 00200
VCID: 408F043C1385833FCF-8015
1 Fault Found:
01314 - Engine Control Module
013 - Check DTC Memory - Intermittent
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-907-044.lbl
Part No: 1K0 907 044 BA
Component: ClimatronicPQ35 066 0606
Shop #: WSC 00000 000 00000
VCID: 67DDFFA0566B94072E-8032
2 Faults Found:
01316 - ABS Control Module
004 - No Signal/Communication
01314 - Engine Control Module
004 - No Signal/Communication
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 3C0-937-049-23-H.lbl
Part No SW: 3C0 937 049 E HW: 3C0 937 049 E
Component: Bordnetz-SG H37 1002
Revision: 00H37000 Serial number: 00000001936888
Coding: E70F8E0700041800001400001400000000087F075C
Shop #: WSC 01279 785 00200
VCID: 2B5543908A0370670A-807E
Subsystem 1 - Part No: 1K2 955 119 C Labels: 1KX-955-119.CLB
Component: Wischer VW350 012 0402
Coding: 00065493
Shop #: WSC 01279
Subsystem 2 - Part No: 1K0 955 559 R Labels: 1K0-955-559-AF.CLB
Component: RegenLichtSens 010 1010
Coding: 00207646
Shop #: WSC 01279
4 Faults Found:
02092 - Enabling Heated Seat
009 - Open or Short to Ground - Intermittent
Freeze Frame:
Fault Status: 00101001
Fault Priority: 5
Fault Frequency: 120
Reset counter: 128
Mileage: 110244 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 11.85 V
ON
ON
OFF
OFF
OFF
01049 - Supply Voltage Term 50
012 - Electrical Fault in Circuit - Intermittent
Freeze Frame:
Fault Status: 00111100
Fault Priority: 1
Fault Frequency: 4
Reset counter: 107
Mileage: 118573 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 12.20 V
OFF
ON
ON
OFF
OFF
01321 - Control Module for Airbags (J234)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 192
Reset counter: 128
Mileage: 110244 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 11.90 V
ON
ON
OFF
OFF
OFF
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 192
Reset counter: 128
Mileage: 110244 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 11.95 V
ON
ON
OFF
OFF
OFF
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1K0-909-605.lbl
Part No SW: 1K0 909 605 N HW: 1K0 909 605 N
Component: 2F AIRBAG VW8 015 2100
Revision: 03015000 Serial number: 0038ED0FEKTU
Coding: 0012870
Shop #: WSC 01269 785 00200
VCID: 377D6FE0464BC4877E-8062
Subsystem 1 - Serial number: 6332MSME0A7E314DN
Subsystem 2 - Serial number: 6342MSME0A7E1D26P
Subsystem 3 - Serial number: 6351HSME07521F2BA
Subsystem 4 - Serial number: 6361HSME07485A7CL
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY8.lbl
Part No SW: 1K0 953 549 AF HW: 1K0 953 549 AF
Component: Lenksäulenmodul 634 0070
Coding: 0000042
Shop #: WSC 01279 785 00200
VCID: 76E3A2E401C17D8FA5-8023
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 1K0-920-xxx-17.lbl
Part No: 1K6 920 972
Component: KOMBIINSTRUMENT VDD 1112
Coding: 0007403
Shop #: WSC 56912 001 1048576
VCID: 6FED97807E9B4C4766-803A
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530-V1.clb
Part No SW: 1K0 907 530 F HW: 1K0 907 951
Component: Gateway H10 0120
Revision: H10 Serial number: 2800105611071D
Coding: 7D3F0348070003
Shop #: WSC 01279 785 00200
VCID: 2A5B469485F9696FF1-807F
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 1K0-920-xxx-25.clb
Part No: 1K6 920 972
Component: IMMO VDD 1112
Shop #: WSC 00840 941 95492
VCID: 6FED97807E9B4C4766-803A
No fault code found.
-------------------------------------------------------------------------------
Address 37: Navigation Labels: 1T0-919-887.lbl
Part No: 1T0 919 887 E
Component: Navigation 0525
Coding: 0000002
Shop #: WSC 01279 785 00200
VCID: 4487082C079D9F1FEB-8011
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 1K0-959-701-MIN2.lbl
Part No: 1K0 959 701 K
Component: Tuer-SG 024 2348
Coding: 0000692
Shop #: WSC 01279 785 00200
VCID: 366362E441413D8F65-8063
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-14x-44.clb
Part No: 1K2 909 144 J
Component: EPS_ZFLS Kl.5 D04 1606
Shop #: WSC 00000 000 00000
VCID: 33655BF0523328A742-8066
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 1K0-959-433-MAX.clb
Part No SW: 1K0 959 433 AR HW: 1K0 959 433 AR
Component: 01 KSG PQ35 G2 010 0101
Revision: 00010000 Serial number: 00000000000000
Coding: 999802085103087F6D0484057008DFC690A440
Shop #: WSC 00840 941 95492
VCID: 000FC43C5305433F8F-8055
Subsystem 1 - Part No: 1K0 951 605 C
Component: LIN BACKUP HORN H05 1501
Subsystem 2 - Part No: 1K0 907 719 C
Component: Neigungssensor 005 0003
Subsystem 3 - Part No: 1K0 951 177 A
Component: Innenraumueberw.005 0202
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MIN2.lbl
Part No: 1K0 959 702 K
Component: Tuer-SG 024 2348
Coding: 0000692
Shop #: WSC 01279 785 00200
VCID: 377D6FE0464BC4877E-8062
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range Labels: 1T0-907-357.lbl
Part No: 1T0 907 357
Component: Dynamische LWR 0002
Coding: 0000003
Shop #: WSC 01279 785 00200
VCID: 74E798EC17BD6F9F9B-8021
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio Labels: 1T0-035-095.lbl
Part No: 1T0 035 095 A
Component: Radio 0525
Coding: 0001402
Shop #: WSC 01279 785 00200
VCID: 2C57408C8F0D775F03-8079
No fault code found.
-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 1K0-959-703-GEN2.lbl
Part No: 1K0 959 703 F
Component: Tuer-SG 021 2423
Coding: 0000144
Shop #: WSC 01279 785 00200
VCID: 33655BF0523328A742-8066
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 1K0-959-704-GEN2.lbl
Part No: 1K0 959 704 F
Component: Tuer-SG 021 2423
Coding: 0000144
Shop #: WSC 01279 785 00200
VCID: 346758EC573D2F9F5B-8061
No fault code found.
End-------------------------(Elapsed Time: 01:53)--------------------------
-
Disregarding the few on heated seats (due to wires being unhooked) and the typical EVAP one everyone gets.....
The one that most likely caused my limp mode was a failure of coil pack 1? P1335
I replaced my sparks exactly 1 year ago.
Do I replace coil pack number 1 or do I replace all of them with the R8 coil packs?
-
Depends on money. I'd prefer the upgraded R8's all round. By sounds of things they dont fail as oftern if ever. Seems the logical next step if you can.
:happy2:
-
That's actually my preference but they won't be delivered before Friday to Ireland and I've to make a 150mile journey so I better get it replaced.
-
Where do you get a fail of coilpack 1 from?
Read here:
http://wiki.ross-tech.com/wiki/index.php/17743/P1335
-
sh*te! Good spot, I hit P1355 not P1335.
Do you think that's my MAF sensor on the way out?
It's working fine the past 8 drives?
-
Choice of 3 sensors failing or an air leak. Data logging with VCDS will tell you which. Monitor the IAT reading, MAF reading and Coolant Temp reading during normal driving, from cold, through to full throttle runs when warm.
Check fuel trims and Lambda correction for evidence of an air leak, and if trims are high and MAF seems ok - go hunting for a leak
-
Dan you're a gentleman. I've literally just bought VCDS today so all of this logging is new to me.
If it's not too much trouble and you're up for it I'd appreciate a very brief how to on that?
How would monitor these readings from VCDS?
Fuel trims and lambda correction on VCDS?
-
Is the car mapped or standard?
Measuring blocks is what you need. Fuel trim info is given as a clickable link in the Rosstech link i posted above
Find the measuring blocks for the sensors mentioned and check their readings. IAT and Coolant temp should read the same as ambient temp (give or take a degree or 2) before starting the car once it has stood overnight) IAT should stay within 10-20 degrees above ambient on a standard intercooler, Coolant temp shoould get up to low 90's and stay there. MAF will need to be logged when driving to see what figures you are getting.
Fuel trims are block 032, they should be fairly close to zero (less than 10%). More could indicate a leak, or a faulty MAF. Again info can be found through the link i sent.
From a quick google it sounds as if it's either the MAF or an airleak. post up the trim numbers from 032 when you can